Victron Orion XS
Orion XS 12/12-50A 700 Watt DC-DC Battery Charger Engineered from the ground up, the Orion XS redefines adaptive DC-DC battery charging. For use in dual battery systems charged with an (intelligent) alternator. This device not only ensures top-tier performance but also guarantees the safety of your system. The Orion XS serves as a DC-DC battery charger or as a power supply, offering a wide input and output voltage range. This is especially significant in the case of vehicles with a Euro 5 or Euro 6 smart alternator, which often supplies too low charging voltage even when the engine is running or when extended cable lengths, as is often the case in boats and RVs, lead to voltage drops. In such scenarios, precise and controlled charging is imperative to fully charge the service battery while protecting the starter/input battery from discharge.
Features • Adjustable charging current • Smart alternator compatibility
• Comprehensive electronic protection • Can be paralleled to increase output current • Bluetooth Smart enabled
• Adaptive 4-stage charge algorithm • Low temperature shutdown and input undervoltage protection • Remote on/off
• VE.Direct port • IP65 protection
Input voltage range 9-17 V 9 – 35 V
XS 12/12-50A
XS 1400 9 – 35 V 10 – 35 V
Input voltage range
9-17 V 10-17 V
Output voltage adjust range Output voltage tolerance
+/- 0.25% (max)
Output voltage noise
10 mV rms
Input and output current setting range Maximum constant short-circuit current Continuous output power up to 40 °C 1)
1 – 50 A
50 A
Orion XS 12/12-50A DC-DC battery charger
700 W 4)
1400W 4)
Maximum efficiency
98.5 %
No-load current consumption Standby current consumption Can be used as power supply
< 100 mA < 1.5 mA
Yes, output voltage can be set with VictronConnect App COMMUNICATION
VictronConnect App / Bluetooth Smart
Yes
VE.Smart Networking
Yes 2)
VE.Direct
Yes (including DVCC) 3)
OTHER
Operating temperature range
-20 to +60 °C (derating 1.5 % per °C above 40 °C)
Humidity
95 %, non-condensing
Maximum altitude Pollution degree
2000 m
PD2
Orion XS 12/12-50A DC-DC battery charger connection area
Overvoltage category
OVC 1
DC connection
Screw terminals 4AWG (21.2mm 2 )
Maximum cable cross-section
Weight
0.330 kg (0.73 lb) 137.3 x 123.1 x 40 mm (5.4 x 4.85 x 1.6 inch)
0.520 kg (1.14 lb)
138.1 x 124.4 x 53mm (5.44 x 4.9 x 2.1 inch)
Dimensions H x W x D
Protection category
IP65
STANDARDS
Safety
IEC 62477-1
IEC 62477-1
EN 300 328, EN 301 489-1, EN 301 489-17, FCC 15B, ICES-003
EN 300 328, EN 301 489-1, EN 301 489-17, FCC 15B, ICES-003 – all pending
EMC
Automotive Directive
ECE R10-6
ECE R10-6 – all pending
1) This applies to optimal cooling where the product is mounted as indicated in the manual with sufficient free space. In case of limited cooling, e.g. due to insufficient airflow, the charging current will be regulated back sooner. With an improved airflow (e.g. forced airflow), derating will take place far above ambient temperatures of 40 °C. 2) VE.Smart Networking features will be receiving Vsense, Tsense and Isense data from the wireless network, for example from a SmartShunt, BMV or Smart Battery Sense. Synchronised charging is not supported. 3) DVCC compatibility requires Orion XS firmware v1.03 or later and Venus OS firmware v3.20 or later on the GX device 4) This value represents the nominal power level at a typical voltage of 14V (12/12-50A) and 28V (Orion XS 1400). Power is calculated as the product of the applied voltage and current (P = V × I). Examples: 12V × 50A = 600W, 14V × 50A = 700W, 28V x 50A = 1400W
Veloris. The Battery Partner.
158
Made with FlippingBook interactive PDF creator