Trex® Outdoor Lighting Brochure 2024

TREX® SOLAR POST CAP DECKLIGHTING INSTALLATION INSTRUCTIONS TREX® SOLAR POST CAP DECKLIGHTING™ Installation Instructions

HOW TO INSTALL TREX® SOLAR POST CAP LIGHT

HOW TO INSTALL TREX® SOLAR POST CAP LIGHT/ CONTINUED

PARTS

5. Add a small button of

6. Seat the post cap on top of the post sleeve.

HELPFUL TIPS

silicone to the tabs on the bottom of the post cap.

» Install the solar post cap in locations that receive the most amount of sunlight. » If the installation location experiences long periods of temperatures below 32°F (0°C) it is recommended to shut the post cap off to prolong the battery life. » Maintenance - Periodically clean the glass solar panel to be free of dust and debris for optimum charging performance using a water dampened cloth.

TOOLS NEEDED

7. The post cap is ready for use.

CAUTION:

Polarity Key

Do not short the pins of the battery connector. Doing so will damage the battery and may cause it to overheat and burst. When installing a replacement battery the male and femnale connectors have a flat side that MUST MATCH UP for polarity. Do not force the connections together. Failure to match polarity will damage the controller board. Do not puncture or allow sharp objects to come into contact with the battery. Do not attempt removal of battery jacket. Do not dispose of battery in a fire. Do not attempt to alter or modify the battery from its original manufacture design. The battery is intended for use in the TREX Solar Post Cap any other use is prohibited and will void the warranty. Check local regulations for proper battery disposal. Keep out of reach of children. TREX® SOLAR POST CAP DECKLIGHTING™ Installation Instructions

TREX® SOLAR POST CAP DECKLIGHTING™ Operation Parameters

Have Questions? 1–800–BUY–TREX 1. Trex solar post cap lights should be installed in a location with as much direct sunlight as possible for best performance. 2. Shading can reduce the charging performance by as much as 50-80%. 3. Solar light run time is based on: • Angle of sunlight for recharging

Angle of the Sun in Dierent Seasons Summer: • Solar panel 75-100% power

Have Questions? 1–800–BUY–TREX HOW TO INSTALL TREX® SOLAR POST CAP LIGHT/ CONTINUED

NOTE: Construction methods are always improving. Please ensure you have the most up-to-date installation instructions by visiting: trex.com

TSPC-0823

1. Turn the post cap upside down.

2. Press the switch to turn the post cap on.

• Longer daylight and optimal charging performance. Spring/Fall:

• Solar panel 50-75% power • Medium daylight and better charging performance. Winter*:

• Solar panel <50% power • Shorter daylight and low charging performance.

• Sun/Cloud conditions for recharging • Duration of sunlight for recharging • Seasonal conditions for recharging • How clean the solar panel is for charging

*It is not recommended to charge or operate the Trex solar post cap in temperatures below 32°F (0°C).

kWh Hight to Low Map

Eective Charge in Sunlight VS Cloud Coverage

4. Turn the post cap over so the solar panel is facing direct sunlight. LED 1 (Power good) and LED 2 (Charging) will turn on. LED 3 (LED’s On) and the post cap LEDs will turn off.

3. Cover the solar panel and the LED 3 (LED’s On) will turn on as well as the post cap LEDs.

100% 75% 50% 25% <25%

Run times vary significantly with actual daily weather conditions, post cap installation location, battery condition and numerous other factors.

Note if there is not enough sunlight then LED 2 (Charging) may not turn on.

If the installation location experiences long periods of temperatures below 32°F (0°C) it is recommended to shut the post cap o to prolong the battery life.

Note this map provides annual average daily total solar resource. The darker color regions have a higher charge eciency potential while lighter shaded regions have lower eciency potential. This map does not account for daily adverse weather conditions that may occur such as rain, overcast and snow fall.

Have Questions? 1–800–BUY–TREX

NOTE: Construction methods are always improving. Please ensure you have the most up-to-date installation instructions by visiting: trex.com

Have Questions? 1–800–BUY–TREX

NOTE: Construction methods are always improving. Please ensure you have the most up-to-date installation instructions by visiting: trex.com

TSPC-0823

Made with FlippingBook - Online Brochure Maker